行业资讯
摊铺机使用施工中的注意事项
来源：/ 日期：2022-09-19
在摊铺机开始施工之前，应该先做一系列检查，确定大型路面机器设备没有问题方可开始正常作业，那么摊铺机在运行的过程中，我们需要具备怎样的特殊技术要求呢?下面济南摊铺机出租厂家一起来看看出租摊铺机之后施工中的注意事项吧：
Before the construction of the paver, a series of inspections should be carried out to ensure that the large road machinery and equipment are free of problems before normal operation. What special technical requirements do we need to have during the operation of the paver? Now let's take a look at the precautions in the construction after renting the paver from Jinan Paver Rental Factory:
(1)按照施工的严格要求，合理确定摊铺机出租之后的工作速度、摊铺宽度、摊铺厚度、刮板输送器及螺旋分料器转速、斗门开度等技术参数。
(1) According to the strict requirements of construction, reasonably determine the working speed, paving width, paving thickness, speed of scraper conveyor and spiral distributor, bucket door opening and other technical parameters of the paver after lease.
(2)机械在传动的沥青混合料摊铺机机，换档一定须在摊铺机完全停止时进行，并严禁用力挂档。
(2) For asphalt mixture paver driven by machinery, gear shifting must be carried out when the paver is completely stopped, and it is strictly prohibited to shift gears forcibly.
(3)准备卸料时，摊铺机推轮靠近自卸车后轮，自卸车挂空档。摊铺机同时推动两个。
(3) When preparing for unloading, the pusher of the paver is close to the rear wheel of the dump truck, and the dump truck is in neutral. The paver pushes both at the same time.
(4)摊铺机的所有部件和系统，必要时应及时协调和校正。运行速度应保持稳定，停车和启动次数应尽量减少，以保持设备的连续和平衡运行。
(4) All components and systems of the paver shall be timely coordinated and corrected when necessary. The running speed shall be kept stable, and the number of stops and starts shall be minimized to maintain the continuous and balanced operation of the equipment.
(5)严禁操作人员在设备作业时离开驾驶台，无关人员不得在作业时上、下设备，或在驾驶台上停留。
(5) It is strictly forbidden for operators to leave the bridge during equipment operation, and irrelevant personnel shall not get on or off the equipment or stay on the bridge during operation.
(6)摊铺机转场后若是在行驶的过程中，禁止在坡道上换档，或空档下坡滑行。摊铺作业前20-40min，对熨平板进行预热，使其接近沥青混合料的摊铺温度;因故暂停作业时，使用预热系统进行保温，防止熨平板冷却;用电预热时，应先启动发动机。
(6) After the paver is transferred, if it is driving, it is forbidden to shift gears on the ramp or slide downhill in neutral. 20-40min before paving, preheat the screed to make it close to the paving temperature of asphalt mixture; When the operation is suspended for some reason, the preheating system shall be used for heat preservation to prevent the screed from cooling; When preheating with electricity, start the engine first.
In addition, the paver shall be cleaned to remove the mud lumps, sticky sand and asphalt accumulated on the surface of the paver; Clean the dust and oil dirt on the surface of the engine, hydraulic components and other components. Be careful not to get dirt into the oil filler and air filter. More notes on our website Consult!
公司地址：济南市商河县贾庄镇民营经济创业园
公司名称:2023澳门正版资料免费 
备案号：