行业资讯
装载机定期保养要求以及相关内容整理
来源：/ 日期：2022-04-30
装载机如今的使用可以说很是广泛，当然也是基于它的性能优势好，让作业效率得到了很大的提高，但是要注意如果不注意保养就会造成机器的使用寿命降低，下面我们就来讲讲装载机定期保养要求以及相关内容。
The use of loader today can be said to be very extensive, of course, but also based on its performance advantages, so that the efficiency of the operation has been greatly improved, but we should pay attention to if you do not pay attention to maintenance will cause the service life of the machine is reduced, we will talk about the loader regular maintenance requirements and related content.
将装载机停放在水平地面上； 将变速杆置于空档； 将所有辅助杆置于空档； 应用驻车制动器； 关闭发动机； 关闭启动开关并拔下钥匙。
Park the loader on the level ground; Put the gear lever in neutral; Put all auxiliary rods in neutral; Application of parking brake; Shut off the engine; Turn off the starter and remove the key.
每10小时（或日常保养）：绕机检查是否有异常或漏油情况； 检查发动机油位； 检查液压油箱的油位； 检查灯光和仪表； 检查轮胎压力和损坏情况； 将黄油注入驱动轴和各种润滑剂。
Every 10 hours （or daily maintenance） : check whether there is abnormal or oil leakage around the machine; Check the engine oil level; Check the oil level of the hydraulic tank; Check lighting and instrumentation; Check tire pressure and damage; Fill the drive shaft with butter and various lubricants.
每50小时（或一周）保养：拧紧前后传动轴联轴器螺栓； 检查变速箱油位； 检查制动助力器油位； 检查紧急和驻车制动器，如果不合适进行调整； 检查轮胎压力和损坏情况； 润滑前后车架铰接点、后轴摆动架、中间支撑和其他轴承。 如需装载机配件，请联系智造大观。
Every 50 hours （or one week） maintenance: tightening the front and rear drive shaft coupling bolts; Check the gearbox oil level; Check the brake booster oil level; Check emergency and parking brakes and adjust if not suitable; Check tire pressure and damage; Lubricate front and rear frame hinge points, rear swing frame, intermediate support and other bearings. For high quality loader accessories, please contact smart manufacturing.
每100小时（或半个月）保养：清洗发动机缸盖和扭力弯管油冷却器； 检查电池电量，在接缝处涂上一层薄薄的凡士林或黄油； 检查液压油箱的油位。
Every 100 hours （or half a month） maintenance: cleaning engine cylinder head and torque bend oil cooler; Check the battery level and apply a thin layer of vaseline or butter to the joints; Check the oil level in the hydraulic tank.
每250小时（或1个月）保养：济南装载机租赁人员认为应检查轮辋固定螺栓并拧紧扭矩； 检查前后桥油位； 检查工作装置、前后车架应力焊缝及固定螺栓有无裂纹和松动； 更换机油（取决于不同的质量和发动机使用情况）； 检查发动机风扇皮带、压缩机和发电机皮带是否紧固和损坏。
Every 250 hours （or 1 month） maintenance: Ji 'nan loader leasing personnel should check the rim fixing bolts and tighten torque; Check the bridge oil level before and after; Check the working device, front and rear frame stress welds and fixed bolts for cracks and looseness; Oil change （depending on different quality and engine usage）； Check engine fan belts, compressor and generator belts for tightness and damage.
In fact, there is still a lot of time to do the maintenance work, of course, we should pay attention to not excessive maintenance, otherwise it will have the opposite effect, more content to the website for consultation.
公司地址：济南市商河县贾庄镇民营经济创业园
公司名称:2023澳门正版资料免费 
备案号：