行业资讯
水稳搅拌站如何进行良好保养及小心使用？
来源：/ 日期：2023-02-17
水稳搅拌站是有使用寿命的，如果想让济南水稳搅拌站永远都顺利运作，这就需要我们良好的保养以及小心谨慎的使用来延长它的寿命。下面小编为您讲解一番：
The water stabilized mixing plant has a service life. If we want to make Jinan water stabilized mixing plant run smoothly forever, we need good maintenance and careful use to extend its service life. The following editor will explain to you:
水稳料搅拌站停机时，整条生产线内严禁带料，在特殊情况下（如机器故障）非人为停车时，要把线内的料干净，然后再行起动，机器严禁满载和超载起动。
When the water stabilized material mixing plant is shut down, it is strictly forbidden to carry materials in the whole production line. In special circumstances (such as machine failure), when it is not stopped manually, it is necessary to clean the materials in the line before starting. The machine is strictly prohibited to start with full load and overload.
料仓振动器严禁空振或长时间振动（当料仓无料或料少时）操作人员要尽职尽责，出现问题立即停车，机器严禁带病工作，操作人员严禁擅离工作岗位。为保证骨料仓能连续下料，保证计量精度，除砂、石其余材料（土、石灰、粉煤等）必需用皮带上料机上料，不允许用装载机，汽车或挖掘机等直接上料。严格保证各种原材料的颗粒径及含水量。
The silo vibrator shall not vibrate in the air or for a long time (when there is no material or little material in the silo). The operator shall do his duty, stop the machine immediately in case of any problem, and the machine shall not work with disease, and the operator shall not leave the post without permission. In order to ensure the continuous blanking of aggregate silo and the measurement accuracy, other materials except sand and stone (soil, lime, pulverized coal, etc.) must be fed by belt loader, and direct loading by loader, truck or excavator is not allowed. Strictly ensure the particle size and water content of various raw materials.
水稳搅拌站在中安装必须平稳牢固，必须搭设防雨、防砸或保温的工作棚。操作地点经常保持整洁，棚外应挖设排除清洗机械废水的沉淀池。电源接线必须正确，必须要有可靠的保护接零(或保护接地)和漏电保护开关，布线和各部绝缘必须符合规定要求。
The water-stabilized mixing plant must be installed stably and firmly in safety, and a rain-proof, anti-smashing or thermal insulation work shed must be set up. The operation site should always be kept clean and tidy. A sedimentation tank should be dug outside the shed to drain the waste water from cleaning machinery. The power supply wiring must be correct, and there must be reliable protective neutral connection (or protective grounding) and leakage protection switch. The wiring and insulation of each part must meet the specified requirements.
(由电工操作)操作人员必须是经过培训，并经考试合格，取得操作证者，严禁非操作人员操作。操作工必须按清洁、紧固、润滑、调整、防腐的十字作业法，每次对水稳搅拌站进行认真的维护与保养。
(Operated by electricians) The operators must be trained, pass the examination and obtain the operation certificate. Non-operators are prohibited to operate. The operator must carefully maintain the water stabilized mixing plant every time according to the cross operation method of cleaning, fastening, lubricating, adjusting and anti-corrosion.
每次工作开始时，应认真检视各部件有无异常现象。开机前应各部件有无破损，是否良好，机身是否平衡，周围有无障碍，确认没有问题时，方能合闸试机。
At the beginning of each work, carefully inspect all parts for abnormalities. Before starting the machine, check whether all parts are damaged, whether they are in good condition, whether the machine body is balanced, and whether there are obstacles around. Only when it is confirmed that there are no problems can the machine be switched on and tested.
以2~3分钟试运转，滚筒转动平衡，不跳动，不跑偏，运转正常，无异常声响后，再正式生产操作。机械开动后，司机必须思想集中，坚守岗位，不得擅离职守。
After the test run for 2~3 minutes, the drum rotates evenly, without jumping, deviation, normal operation, and no abnormal noise, the formal production operation can be started. After the machine is started, the driver must concentrate on his/her position and not leave without permission.
Pay attention to the operation of the machinery at any time. If abnormal phenomena are found or abnormal noises are heard, the stored materials in the mixer must be discharged and the machine must be shut down for maintenance. When the water stabilized mixing plant is in operation, it is strictly forbidden to repair and maintain it, and it is not allowed to use tools to stretch into the drum to pick up materials. Come to our website for more relevant content Ask!
公司地址：济南市商河县贾庄镇民营经济创业园
公司名称:2023澳门正版资料免费 
备案号：